I have had my 2001 XG300 do this twice now some 10 months & 15,000 km apart.
For no apparent reason the car will suddenly show a 'check engine' light &
at the same time go into 'limp mode'.
The car has only 115,000 Km (about 70,000 mi), has been serviced regularly
& was/is running absolutely perfectly. On both occasions, I was driving
highway speeds in a remote part of Wa state doing the speed limit & slightly
accelerating. On the first event I was over an hour from anywhere with a
code reader, so tried a momentary disconnect of the battery. The problem was
immediately fixed. It ran perfectly for all these 10 months- I even carried
my code reader with me for about 9 months in case it should happen again,
but recently in getting the car ready for winter brought it in the house. So
once again I had to disconnect the battery roadside (not fun at 6:300 AM on
a cold desolate road).
On both occasions there were no codes showing when I got home some 4 hours
of driving later. Until last week, I dismissed the first as a fluke, but
here it's happened again & I have no idea what to look for. By the way last
spring I changed the plugs & checked virtually all electrical connectors
that I could find under the hood. Everything looked good. The car starts
quickly, runs smoothly, has all kinds of power & seems almost perfect. The
almost is b/c at times the remote control for locking doesn't flash the
lights even though it locks & once in a long while the alarm will sound even
when opening a door locked & then unlocked with the remote. I mention this
b/c when the car acted up last week, it also tripped the alarm after I had
reset the computer, drove it for an hour,then stopped and opened the
door -causing the alarm to sound.
Any ideas folks??
Thanks,
BCinBC

 

It's pretty much guaranteed your remote issue is unrelated to the limp-home
issue.

It's also going to be impossible to determine the nature of the problem
causing activation of limp-home without a trouble code. Considering the
problem has only happened twice in ten months now, the chances of finding
it without retrieving a code (and taking a guess based off that code) are
near zero.

When you use the term "limp-home," do you mean that the transmission
shifts to and stays in third gear, or that engine power is reduced to near
zero.

--
Message posted using http://www.talkaboutautos.com/group/alt.autos.hyundai/
More information at http://www.talkaboutautos.com/faq.html

 

Thanks for responding hyundaitech,
I don't know what gear it drops to, but last week it cut out as the
service light came on just as I was ascending a mid grade hill. I had maybe
500' to go to get past the guard rail & onto a wider shoulder. The engine
was running very rough & it was a chore to make it at about 5 to 10 mph.
When I put it neutral , I thought it would stall & trying to rev it didn't
really make much of a change -speeded up a bit but just as rough. As I said
a quick battery disconnect for 30 seconds & then it fired right up & has run
perfectly again for a good 800 km. of mostly mountain driving. I guess I'm
just going to have to be sure to carry my code reader. The other odd thing
is that the door locks are now working correctly -every time I lock the
lights flash twice. For the previous month frequently the doors would lock
from the remote but no flash & sometimes I'd hear a click but they didn't
lock. Weird, I realize & yes most likely a red herring but then again the
whole event is bizarre.
BCinBC
"hyundaitech" <notpublic@not.public.com> wrote in message
news:e663e158b0369cf927bf6271f7d94418@localhost.ta lkaboutautos.com...
> It's pretty much guaranteed your remote issue is unrelated to the
> limp-home
> issue.
>
> It's also going to be impossible to determine the nature of the problem
> causing activation of limp-home without a trouble code. Considering the
> problem has only happened twice in ten months now, the chances of finding
> it without retrieving a code (and taking a guess based off that code) are
> near zero.
>
> When you use the term "limp-home," do you mean that the transmission
> shifts to and stays in third gear, or that engine power is reduced to near
> zero.
>
> --
> Message posted using
> http://www.talkaboutautos.com/group/alt.autos.hyundai/
> More information at http://www.talkaboutautos.com/faq.html
>

 

Since the engine performance is limited, it's definitely and engine control
related issue. Typically, it's either with the accelerator position
sensor, or some issue with the throttle body or one of its components.

Next time, try turning the car off and restarting. It may not be
necessary to disconnect the battery, but rather just start a new key
cycle.

--
Message posted using http://www.talkaboutautos.com/group/alt.autos.hyundai/
More information at http://www.talkaboutautos.com/faq.html

 

Thanks again Hyundaitech,
> Yes I tried just restarting on both the first & now second event & no it
> did not make
> a difference. I have replaced the mass air flow sensor (an issue with this
> model) & reset the throttle sensor over a year ago. Also when I changed
> the
> plugs after the first weird event I checked all connectors under the hood
> &
> all looked good to me.
> The last silly consideration is that it may be related to the security
> system. I say this b/c both times this has happened was just outside of
> Spokane Wa. Now to come back to BC, Canada where we live, from the
> airport,
> you have to go through a bit of a seedy part of town. On both occasions,
> it
> was about 3/4 hours after leaving Spokane & each time I had locked the
> doors
> from the inside. These are the only times since I owned this car new that
> I
> have done so. Coincidence?? Don't know.
> BCinBC
"hyundaitech" <notpublic@not.public.com> wrote in message
news:57c151b60b7cd4ec76512ad81caf8b0f@localhost.ta lkaboutautos.com...
> Since the engine performance is limited, it's definitely and engine
> control
> related issue. Typically, it's either with the accelerator position
> sensor, or some issue with the throttle body or one of its components.
>
> Next time, try turning the car off and restarting. It may not be
> necessary to disconnect the battery, but rather just start a new key
> cycle.
>
> --
> Message posted using
> http://www.talkaboutautos.com/group/alt.autos.hyundai/
> More information at http://www.talkaboutautos.com/faq.html
>

 

I had a similar problem a few years ago with an XG300. They replaced the
throttle body and it worked for a while, but went out again and the problem
turned out to be a wiring issue and not the throttle body. Hyundai
reimbursed me for the throttle body cost and once the frayed wires were
repaired it ran ok.

Might want to check the wiring before major repairs.


"B Crawford" <bcdcinbc@telus.net> wrote in message
news:L%PVi.42565$GO5.20520@edtnps90...
> Thanks again Hyundaitech,
>> Yes I tried just restarting on both the first & now second event & no it
>> did not make
>> a difference. I have replaced the mass air flow sensor (an issue with
>> this
>> model) & reset the throttle sensor over a year ago. Also when I changed
>> the
>> plugs after the first weird event I checked all connectors under the hood
>> &
>> all looked good to me.
>> The last silly consideration is that it may be related to the security
>> system. I say this b/c both times this has happened was just outside of
>> Spokane Wa. Now to come back to BC, Canada where we live, from the
>> airport,
>> you have to go through a bit of a seedy part of town. On both occasions,
>> it
>> was about 3/4 hours after leaving Spokane & each time I had locked the
>> doors
>> from the inside. These are the only times since I owned this car new that
>> I
>> have done so. Coincidence?? Don't know.
>> BCinBC
> "hyundaitech" <notpublic@not.public.com> wrote in message
> news:57c151b60b7cd4ec76512ad81caf8b0f@localhost.ta lkaboutautos.com...
>> Since the engine performance is limited, it's definitely and engine
>> control
>> related issue. Typically, it's either with the accelerator position
>> sensor, or some issue with the throttle body or one of its components.
>>
>> Next time, try turning the car off and restarting. It may not be
>> necessary to disconnect the battery, but rather just start a new key
>> cycle.
>>
>> --
>> Message posted using
>> http://www.talkaboutautos.com/group/alt.autos.hyundai/
>> More information at http://www.talkaboutautos.com/faq.html
>>
>
>

 

Thanks Dwight,
The wiring on these cars is extremely involved. Do you have any idea as to
where the wiring problem was located?
Thanks,
BCinBC
"Dwight Jones" <4dwight@comcast.net> wrote in message
news:4MidnTFHAKfReLranZ2dnUVZ_gadnZ2d@comcast.com. ..
>I had a similar problem a few years ago with an XG300. They replaced the
>throttle body and it worked for a while, but went out again and the problem
>turned out to be a wiring issue and not the throttle body. Hyundai
>reimbursed me for the throttle body cost and once the frayed wires were
>repaired it ran ok.
>
> Might want to check the wiring before major repairs.
>
>
> "B Crawford" <bcdcinbc@telus.net> wrote in message
> news:L%PVi.42565$GO5.20520@edtnps90...
>> Thanks again Hyundaitech,
>>> Yes I tried just restarting on both the first & now second event & no it
>>> did not make
>>> a difference. I have replaced the mass air flow sensor (an issue with
>>> this
>>> model) & reset the throttle sensor over a year ago. Also when I changed
>>> the
>>> plugs after the first weird event I checked all connectors under the
>>> hood &
>>> all looked good to me.
>>> The last silly consideration is that it may be related to the security
>>> system. I say this b/c both times this has happened was just outside of
>>> Spokane Wa. Now to come back to BC, Canada where we live, from the
>>> airport,
>>> you have to go through a bit of a seedy part of town. On both occasions,
>>> it
>>> was about 3/4 hours after leaving Spokane & each time I had locked the
>>> doors
>>> from the inside. These are the only times since I owned this car new
>>> that I
>>> have done so. Coincidence?? Don't know.
>>> BCinBC
>> "hyundaitech" <notpublic@not.public.com> wrote in message
>> news:57c151b60b7cd4ec76512ad81caf8b0f@localhost.ta lkaboutautos.com...
>>> Since the engine performance is limited, it's definitely and engine
>>> control
>>> related issue. Typically, it's either with the accelerator position
>>> sensor, or some issue with the throttle body or one of its components.
>>>
>>> Next time, try turning the car off and restarting. It may not be
>>> necessary to disconnect the battery, but rather just start a new key
>>> cycle.
>>>
>>> --
>>> Message posted using
>>> http://www.talkaboutautos.com/group/alt.autos.hyundai/
>>> More information at http://www.talkaboutautos.com/faq.html
>>>
>>
>>
>
>

 

don't recall, sorry
"B Crawford" <bcdcinbc@telus.net> wrote in message
news:TxbWi.79453$%B2.72156@edtnps82...
> Thanks Dwight,
> The wiring on these cars is extremely involved. Do you have any idea as to
> where the wiring problem was located?
> Thanks,
> BCinBC
> "Dwight Jones" <4dwight@comcast.net> wrote in message
> news:4MidnTFHAKfReLranZ2dnUVZ_gadnZ2d@comcast.com. ..
>>I had a similar problem a few years ago with an XG300. They replaced the
>>throttle body and it worked for a while, but went out again and the
>>problem turned out to be a wiring issue and not the throttle body. Hyundai
>>reimbursed me for the throttle body cost and once the frayed wires were
>>repaired it ran ok.
>>
>> Might want to check the wiring before major repairs.
>>
>>
>> "B Crawford" <bcdcinbc@telus.net> wrote in message
>> news:L%PVi.42565$GO5.20520@edtnps90...
>>> Thanks again Hyundaitech,
>>>> Yes I tried just restarting on both the first & now second event & no
>>>> it did not make
>>>> a difference. I have replaced the mass air flow sensor (an issue with
>>>> this
>>>> model) & reset the throttle sensor over a year ago. Also when I changed
>>>> the
>>>> plugs after the first weird event I checked all connectors under the
>>>> hood &
>>>> all looked good to me.
>>>> The last silly consideration is that it may be related to the security
>>>> system. I say this b/c both times this has happened was just outside of
>>>> Spokane Wa. Now to come back to BC, Canada where we live, from the
>>>> airport,
>>>> you have to go through a bit of a seedy part of town. On both
>>>> occasions, it
>>>> was about 3/4 hours after leaving Spokane & each time I had locked the
>>>> doors
>>>> from the inside. These are the only times since I owned this car new
>>>> that I
>>>> have done so. Coincidence?? Don't know.
>>>> BCinBC
>>> "hyundaitech" <notpublic@not.public.com> wrote in message
>>> news:57c151b60b7cd4ec76512ad81caf8b0f@localhost.ta lkaboutautos.com...
>>>> Since the engine performance is limited, it's definitely and engine
>>>> control
>>>> related issue. Typically, it's either with the accelerator position
>>>> sensor, or some issue with the throttle body or one of its components.
>>>>
>>>> Next time, try turning the car off and restarting. It may not be
>>>> necessary to disconnect the battery, but rather just start a new key
>>>> cycle.
>>>>
>>>> --
>>>> Message posted using
>>>> http://www.talkaboutautos.com/group/alt.autos.hyundai/
>>>> More information at http://www.talkaboutautos.com/faq.html
>>>>
>>>
>>>
>>
>>
>
>